A little something to keep me busy

Collapse
X
 
  • Time
  • Show
Clear All
new posts
  • AndyP
    S2Forum Zealot
    • Feb 2004
    • 6049
    • Country: England

    #166
    Originally posted by Tractor Dave

    Now I have a small dilemma. The basket was removed no problem but the basket holder appears to be bonded to the bottom of the tank and is way too big to fit through the hole. If I use tank sealer in here, will I still get the basket back in?




    Sent from my iPhone using Tapatalk
    The basket holder is bolted to the bottom of the tank on 3 captive studs. I had mine out recently, but my tank was rotten and I had to chop the bottom out to replace it, the nut are tricky to get to even with it on the bench, wouldn't like to try it in the tank!

    sigpic
    1991 Audi S2 3B - 2.5 Stroker engine
    1997 A6 2.5TDi quattro avant - C4
    1976 RD250E / 350LC cafe racer

    Comment

    • Nuvo
      S2Forum Possessed
      • Nov 2003
      • 3825

      #167
      The fabrication work on the front wing is very impressive indeed. Top marks to Ashley.

      Comment

      • Tractor Dave
        S2Forum Zealot
        • Dec 2017
        • 5987
        • Country: Wales

        #168
        Originally posted by K Simmonds
        Hmm, that's a conundrum... I'd have thought there's enough flex in the basket and holder to allow it be refitted but I wouldn't want to bet on it and once you've done it there's no going back.

        Where's the tank leaking from, the seam?
        I've been mulling this over whilst walking the dog tonight. It is the seam and internally it looks very clean. I reckon if I keep the sealer away from the basket and just run it around the seams I should be ok
        Nothelle S2 Avant
        Black Ur project
        Silver Rs2 Project gone
        Ocianic Ur project gone
        S2 Coupe project gone
        Urs6 plus project gone

        Comment

        • Tractor Dave
          S2Forum Zealot
          • Dec 2017
          • 5987
          • Country: Wales

          #169
          Originally posted by AndyP

          The basket holder is bolted to the bottom of the tank on 3 captive studs. I had mine out recently, but my tank was rotten and I had to chop the bottom out to replace it, the nut are tricky to get to even with it on the bench, wouldn't like to try it in the tank!
          I did remove the three nuts but found it was bonded as well. No way it's fitting through the hole anyway.
          Nothelle S2 Avant
          Black Ur project
          Silver Rs2 Project gone
          Ocianic Ur project gone
          S2 Coupe project gone
          Urs6 plus project gone

          Comment

          • Tractor Dave
            S2Forum Zealot
            • Dec 2017
            • 5987
            • Country: Wales

            #170
            Originally posted by Nuvo
            The fabrication work on the front wing is very impressive indeed. Top marks to Ashley.
            He is very good.
            Nothelle S2 Avant
            Black Ur project
            Silver Rs2 Project gone
            Ocianic Ur project gone
            S2 Coupe project gone
            Urs6 plus project gone

            Comment

            • Tractor Dave
              S2Forum Zealot
              • Dec 2017
              • 5987
              • Country: Wales

              #171
              The tank needed a scrub to get all the caked up oil off. The holes got sealed up first to stop any dirt getting inside.




              Then I was ready to do battle.


              It didn't take long to find where it had been leaking.


              And I also swapped to a nylon brush. I didn't want to blow myself up with petrol fumes still in the tank.

              After a couple of hours it came up quite well. No other holes found. It then got a coat of Bilt rust treatment.


              On to rear bumper removal. Another shock!


              What the trick to getting the bumper to release after the bolts have been removed? I can slide it back and forward but the two side brackets won't release?


              Sent from my iPhone using Tapatalk
              Nothelle S2 Avant
              Black Ur project
              Silver Rs2 Project gone
              Ocianic Ur project gone
              S2 Coupe project gone
              Urs6 plus project gone

              Comment

              • anthonys2
                S2Forum Possessed
                • Mar 2009
                • 3512
                • Country: England

                #172
                Dave been following this thread and amazing work as usual your attention to detail is nothing short of phenomenal

                Comment

                • Tractor Dave
                  S2Forum Zealot
                  • Dec 2017
                  • 5987
                  • Country: Wales

                  #173
                  Originally posted by anthonys2
                  Dave been following this thread and amazing work as usual your attention to detail is nothing short of phenomenal
                  Thanks
                  Nothelle S2 Avant
                  Black Ur project
                  Silver Rs2 Project gone
                  Ocianic Ur project gone
                  S2 Coupe project gone
                  Urs6 plus project gone

                  Comment

                  • Tractor Dave
                    S2Forum Zealot
                    • Dec 2017
                    • 5987
                    • Country: Wales

                    #174
                    Tank repair options.
                    Get a patch welded in,
                    Use solder in the holes,
                    Use special petrol proof epoxy repair putty,
                    Braise rod,
                    Lead load.
                    The inside will be sealed after any repair with a special tank sealer and the outside will be epoxy painted.
                    Views appreciated
                    Nothelle S2 Avant
                    Black Ur project
                    Silver Rs2 Project gone
                    Ocianic Ur project gone
                    S2 Coupe project gone
                    Urs6 plus project gone

                    Comment

                    • K Simmonds
                      S2Forum Zealot
                      • Dec 2007
                      • 7627
                      • Country: Wales

                      #175
                      That whole area look's quite thin and pitted, I think I'd weld a new patch in.

                      I can't help with the rear bumper, am at the same point with my saloon, it moves back and forth two inches but won't come off.
                      1990 B3 2.0 80 quattro.
                      1992 C4 2.8 Avant quattro
                      1994 MTM RS2.
                      1998 B5 TDI quattro Sport.
                      2000 B5 TQS.

                      Comment

                      • Nuvo
                        S2Forum Possessed
                        • Nov 2003
                        • 3825

                        #176
                        Originally posted by Tractor Dave
                        What the trick to getting the bumper to release after the bolts have been removed? I can slide it back and forward but the two side brackets won't release?
                        Have you removed the combi bolts from the wheel arch liners?

                        Comment

                        • Tractor Dave
                          S2Forum Zealot
                          • Dec 2017
                          • 5987
                          • Country: Wales

                          #177
                          Bumper sorted. You have to push hard down on the bumper next to the bracket and at the same time pull the bottom out. It wasn't working and I guessed the plastic had gone a bit hard with time. I warmed it up with the heat gun on lowest setting and it popped right out
                          Nothelle S2 Avant
                          Black Ur project
                          Silver Rs2 Project gone
                          Ocianic Ur project gone
                          S2 Coupe project gone
                          Urs6 plus project gone

                          Comment

                          • Tractor Dave
                            S2Forum Zealot
                            • Dec 2017
                            • 5987
                            • Country: Wales

                            #178


                            This was an accident waiting to happen.


                            I wonder if this car was used to launch a small boat n the sea? All the back end is rusty.


                            Sent from my iPhone using Tapatalk
                            Nothelle S2 Avant
                            Black Ur project
                            Silver Rs2 Project gone
                            Ocianic Ur project gone
                            S2 Coupe project gone
                            Urs6 plus project gone

                            Comment

                            • K Simmonds
                              S2Forum Zealot
                              • Dec 2007
                              • 7627
                              • Country: Wales

                              #179
                              That's some nasty corrosion and as you say a serious accident waiting to happen. I was also wondering if this car has been in regular contact with salt water, it's really exceptionally rusty for an Audi.

                              Right, I know how to tackle the bumper now, thanks.
                              1990 B3 2.0 80 quattro.
                              1992 C4 2.8 Avant quattro
                              1994 MTM RS2.
                              1998 B5 TDI quattro Sport.
                              2000 B5 TQS.

                              Comment

                              • jbrentd
                                S2Forum Addict
                                • Dec 2009
                                • 247
                                • Country: United States

                                #180
                                You sir, deserve a medal of some sorts...and a tetanus shot!
                                2001 A4 Avant QMS - FXK04'd
                                1991 Audi CQ - Project
                                1996 A4 12v Quattro Manual - SOLD

                                Comment

                                Working...