Announcement

Collapse
No announcement yet.

80q b4 2.2 20vt project

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • Hehe i skipped mine and used a 60mm Wastegate from turbosmart instead. That Will hold haha

    Comment


    • Originally posted by s2dk View Post
      Hehe i skipped mine and used a 60mm Wastegate from turbosmart instead. That Will hold haha
      Yea, thats 40e versus 650e lol

      Audi UrS4 Avant 2.5 20vt - twincharged - Project
      Audi 80q B4 Sedan 2.2 20vt - Daily user
      BMW 320d Touring e91 M-Sport - Daily user
      BMW 740iA e38 - Project

      Comment


      • i got it very cheap. it was used so i payed 120 euro only and its a original turbosmart

        Comment


        • Now the b4 is running again. Yesturday we swapped a new 01A trans in on my friends car lifter. The new trans is from an totalled S2, so had to swap over the old 100mm driveshaft flanges.







          Everything got quite smooth without any bigger problems. But when I took the car for testdrive there was a quote loud abrasive clicking sound. Not good. Anyway drove it home, and today looked under the car to see if there is anything strange visible... Turned the propshaft over few times and this was how it sounded:

          https://youtu.be/p4yRqKc1VzU

          The noise seemd to come from the rear part of the trans, and in fact the rear part was slightly bended, propably in the crash. Seemd that it has got a hard hit. Maybe the bearing was broken? It had also started to leak oil.



          So i decided to swap over the whole rear part, the torsen diff cover from the old trans. Small vid of the two torsen covers...

          https://youtu.be/nZ6ERfG1eLA

          But it fixed the problem and now everything works fine... Untill it's time to do the 01E swap...

          Audi UrS4 Avant 2.5 20vt - twincharged - Project
          Audi 80q B4 Sedan 2.2 20vt - Daily user
          BMW 320d Touring e91 M-Sport - Daily user
          BMW 740iA e38 - Project

          Comment


          • Some small things done again. Changed oil and filter today, had to test cheap Mannol 10W-60 racing oil. Just for summer use. Have to use something else in the winter. When the oil was out, I decided to make an oil drain back to the sump. As I don't have any bung in the oil pan I had to mod the drain plug. The catch can had a threaded(plugged) hole in the bottom, so it was very easy to add.








            Also all needed parts for the 01E swap has been found. B5 2.5tdi prop shaft which is the same as S4/RS4, 6 gear shifter, 6 gear linkage, 100mm driveshaft flanges and mount protos made. Thanks to JuizeR for the prop shaft and 6 gear shifter.






            ​​​​​



            ​​​​​​
            ​​​​​​​Now just waiting to break the 01A

            Audi UrS4 Avant 2.5 20vt - twincharged - Project
            Audi 80q B4 Sedan 2.2 20vt - Daily user
            BMW 320d Touring e91 M-Sport - Daily user
            BMW 740iA e38 - Project

            Comment


            • Originally posted by Thuppu View Post
              ​​​​​​
              Now just waiting to break the 01A
              ​​​​​​​we know you can, go for it

              Comment


              • Nice mounts Thomas
                The clock is ticking on that 01A now
                Panthero Coupé quattro 20vt
                Indigo ABY coupé
                Imola B6 S4 Avant

                Comment


                • To keep the promise of destroying the 01A() I had some dyno mapping today. Car worked fine without any faults or issues, but the 500hp level seem to be hard for this small a/r .48 turbine housing. Best result was 496hp, but it was on the knock limit so the tuner reduced the timing a bit. Safe result is 488hp/621Nm.



                  https://www.youtube.com/watch?v=kR3bPLLIT6g

                  Audi UrS4 Avant 2.5 20vt - twincharged - Project
                  Audi 80q B4 Sedan 2.2 20vt - Daily user
                  BMW 320d Touring e91 M-Sport - Daily user
                  BMW 740iA e38 - Project

                  Comment


                  • Looking good any plans of going any circuit driving or drag?
                    Project Audi s2 coupé 1996

                    http://http://www.s2forum.com/forum/showthread.php?t=80796]

                    Comment


                    • Very nice flat power curve

                      Sent from my Moto G (5) using Tapatalk

                      Comment


                      • Filip, yea, next weekend 1/4 mile drag race. Also Botniaring audifinns track day is planned if the car is fine.

                        Des, boost tapers down quite a lot, keeps the curve flat. The extra torque is nice compared to previous result.

                        Audi UrS4 Avant 2.5 20vt - twincharged - Project
                        Audi 80q B4 Sedan 2.2 20vt - Daily user
                        BMW 320d Touring e91 M-Sport - Daily user
                        BMW 740iA e38 - Project

                        Comment


                        • Yes it makes a nice driving car having a power graph like that. Similar graph to my urs4 with efr6758

                          Sent from my Moto G (5) using Tapatalk

                          Comment


                          • Very nice Thomas, to me it looks perfect for an aggressive road car.
                            Now then, 1/4 mile with 600nm will surely be the final straw for the 01A
                            Panthero Coupé quattro 20vt
                            Indigo ABY coupé
                            Imola B6 S4 Avant

                            Comment


                            • Whats the final spec of the engine and what management if you don't mind me asking?

                              Also quite a lot of vapor out the breather system is that normal?

                              Comment


                              • Originally posted by diesel des View Post
                                Yes it makes a nice driving car having a power graph like that. Similar graph to my urs4 with efr6758

                                Sent from my Moto G (5) using Tapatalk
                                Do you have dynosheet with this turbo?
                                .: Audi Coupe Quattro 20V 91' :.
                                .: Audi/PorscheRS2 95' :.
                                .: Mitsubishi 3000GT VR-4 96' :.

                                Comment

                                Working...
                                X